Click on Picture to enlarge

 

Click on Picture to enlarge

The Allison T40

The Allison T40 was the production version of the YT40. It was an attempt to produce a high power turboprop engine by combining two T38 turbo shaft engines side-by-side with a joint gearbox to combine power and reduce shaft speed to that necessary for a propeller. This combination was inevitably used with a contra-rotating propellers system.

In the late 1940s and early 1950s this engine was favored by the US Navy and was used in several aircraft, the XA2D, XA2J, P5Y, R3Y, and the two VTOL developments, the XFV-1 and XFY-1.

As the individual power plants were clutched into the gearbox, it was intended in most instances that the aircraft could cruise on one half the engine and only engage the second power-section when there was need. In practice the system did not work so well. Failure to recognize that one of the T38s had failed, and its compressor was devouring power produced by the other section, led to the loss of the first prototype XA2D-1 and its pilot Lt. Cmdr. Hugh Wood on 14 December 1950.

The major problems of the T40 were its fragile gearbox, and the prop-control system which used 25 vacuum tubes, and was far from reliable.

The T40 never produced the 5,500 horsepower it was supposed to deliver, and was plagued by gearbox failures, runaway props and prop control failures.

The failure of the T40 was a blow to navy aviation in the early 1940s almost as severe as the even bigger J40 fiasco which affected diverse but important programs such as the F4D, A3D, and F3H.

The only aircraft using the T40 to actually enter service was the Convair R3Y-1 and R3Y-2. Those large four-engine flying boats served primarily between Alameda and Hawaii during the mid-1950s (replacing the Martin Mars flying boats).

Numerous problems with the T40s, ending in a near disaster where a R3Y managed to land with a runaway engine, resulting in a collision with a seawall in 1958, caused the Navy to ground the R3Y.

The T38 became the basis for the very successful family of Allison T56 turboprop engines which have been in service starting with the C-130 over 50 years ago.^[

 

USE YOUR BROWSER "BACK" BUTTON TO RETURN TO PERVIOUS PAGE